SciELO - Scientific Electronic Library Online

 
vol.68 issue3Exclusive breastfeeding counseling at Women and Children Friendly Institutions of Bogotá D.C., ColombiaTorque estimation based on surface electromyography: potential tool for knee rehabilitation author indexsubject indexarticles search
Home Pagealphabetic serial listing  

Services on Demand

Journal

Article

Indicators

Related links

  • On index processCited by Google
  • Have no similar articlesSimilars in SciELO
  • On index processSimilars in Google

Share


Revista de la Facultad de Medicina

Print version ISSN 0120-0011

rev.fac.med. vol.68 no.3 Bogotá July/Sept. 2020  Epub Nov 23, 2020

https://doi.org/10.15446/revfacmed.v68n3.73188 

Review article

Formaldehyde in occupational environments: literature review and an occupational health surveillance proposal

Formaldehído en ambientes laborales: revisión de la literatura y propuesta de vigilancia ocupacional

Marisol Margarita Villadiego-Molinares1  * 
http://orcid.org/0000-0002-3942-8560

Johanna Alejandra Ramírez-Martínez1 
http://orcid.org/0000-0003-4500-5174

Alba Isabel Rodriguez-Pulido1 
http://orcid.org/0000-0002-1589-2019

1 Universidad Nacional de Colombia - Bogotá Campus- Faculty of Medicine - Master's degree in Toxicology - Bogotá D.C. - Colombia.


Abstract

Introduction:

Formaldehyde is a substance widely used in the industry; however, it is classified as mutagenic and carcinogenic to humans. In order to determine the risk of workers who are occupationally exposed to formaldehyde, it is necessary to monitor its environmental concentration levels and the biomarkers that allow identifying its potential health effects. Unfortunately, in Colombia there are not guidelines on occupational exposure to this substance.

Objective:

To review recent studies on occupational exposure to formaldehyde to design a monitoring and surveillance strategy for Colombian workers exposed to this substance.

Materials and methods:

A literature review was conducted in PubMed, MedLine, Science-Direct and Embase using the following search strategy: articles on occupational exposure to formaldehyde published in English or Spanish between 2013 and 2017. The following search terms were used: "occupational exposure", "formaldehyde" "mutagenicity test" y "DNA adducts" and their Spanish equivalents.

Results:

The initial search yielded 103 articles, of which only 36 met the inclusion criteria.

Conclusions:

Proper management of the risk derived from occupational exposure to formaldehyde, as well as the appropriate medical follow-up of these workers, requires the implementation of a series of interdisciplinary actions that allow the creation of a comprehensive occupational health surveillance system for workers exposed to this substance.

Keywords: Occupational Exposure; Mutagenicity Tests; Biomarkers; Formaldehyde (MeSH)

Resumen

Introducción.

El formaldehido es una sustancia ampliamente usada a nivel industrial; sin embargo, es considerada un agente mutagénico y carcinógeno para los humanos. Para determinar el grado de riesgo de los trabajadores ocupacionalmente expuestos (TOE) al formaldehido, debe hacerse un seguimiento de sus niveles de concentración ambiental y de los biomarcadores que permiten identificar su daño potencial para la salud. En Colombia, lamentablemente, no existen lineamientos respecto a la exposición ocupacional a esta sustancia.

Objetivo.

Revisar estudios recientes sobre exposición ocupacional a formaldehido para diseñar una estrategia de seguimiento y vigilancia de los TOE a esta sustancia en Colombia.

Materiales y métodos.

Se realizó una revisión de la literatura en PubMed, MedLine, ScienceDirect y Embase mediante la siguiente estrategia de búsqueda: artículos sobre exposición ocupacional a formaldehido publicados en inglés o español entre 2013 y 2017. Los términos de búsqueda fueron "occupational exposure", "formaldehyde" "mutagenicity test" y "DNA adducts" y sus equivalentes en español.

Resultados.

La búsqueda inicial arrojó 103 registros, sin embargo solo 36 artículos cumplieron los criterios de inclusión establecidos.

Conclusiones.

La gestión adecuada del riesgo derivado de la exposición ocupacional a formaldehido, asi como el seguimiento médico apropiado de estos trabajadores, requiere la implementación de una serie de acciones interdisciplinarias que permitan la creación de un sistema de vigilancia ocupacional integral de los TOE a esta sustancia.

Palabras clave: Exposición ocupacional; Pruebas de mutagenicidad; Biomarcadores; Formaldehido (DeCS)

Introduction

In Colombia, the Sistema de Gestión de Seguridad y Salud en el Trabajo (Occupational Health and Safety Management System) considers formaldehyde (FA) as a priority substance 1 since it is included in the list of carcinogens of interest to the Sistema de Vigilancia del Cáncer Ocupacional (Occupational Cancer Surveillance System)2 developed by the Instituto Nacional de Can-cerología (National Cancer Institute.)3

Even though the Occupational Diseases List published by the Ministry of Labor4,5 includes some of the pathologies associated with exposure to FA -such as acute bronchitis caused by chemical agents, pulmonary edema caused by chemical agents, inflammation of the upper respiratory tract caused by chemical agents, chronic diffuse emphysema, reactive airways dysfunction syndrome, pulmonary fibrosis, obliterative bronchiolitis and toxic effects-, diseases related to the carcinogenic potential of this substance have not been considered.

FA is a volatile organic compound with a characteristic and irritating odor, characterized by having a double bond with oxygen (H2C=O), which promotes its reactivity. FA is used dissolved in water at a maximum concentration of 40% and is produced on a large scale worldwide. An estimated 21 million tons per year6 of this compound are used to manufacture a large number of industrial products such as urea and melamine phenolic resins, which have various applications in adhesives and binders; wood products such as cellulose pulp for making paper; plastic products; paints for coatings; and products for the textile industry.7 In other areas, including the clinical field, it is used directly in aqueous solution as a disinfectant, tissue preservative, and biocide.

The main route of exposure to FA is inhalation8 and, depending on its concentration, exposure to this compound can cause different symptoms. At concentrations of 0.1-5ppm, it can cause eye irritation, tearing, upper respiratory tract irritation and coughing; at concentrations of 5-30ppm, it can cause chest pain, airway irritation, respiratory distress, headache, asthmatic reactions and can aggravate pre-existing respiratory conditions;9-11 and at concentrations of 50-100ppm, it can cause pneumonia, pulmonary edema and even death.12,13 Permanent exposure to lower concentrations of FA can produce nasopharyngeal and squamous cell carcinoma in the tissues of the nose.7

The International Agency for Research on Cancer14 classifies FA in the group of agents that are carcinogenic to humans (Group 1). Recent meta-analyses have reported a strong association between exposure to this substance and acute myeloid leukemia,15 while other studies with limited evidence have established a link between FA and sinus cancer.16-18

Other consequences of FA exposure have been reported. For example, Lino et al.19 found that this substance produces alterations in the physiological balance between oxidative and antioxidant enzymes in lung tissue, most likely favoring the oxidative pathway and generating lung inflammation. Schwensen et al.20 explained that skin irritation occurs after having contact with this substance and that this, in turn, can produce contact dermatitis. Thrasher et al.21 reported an association between recurrent exposure to this substance and immune system disorders since, in humans, FA conjugates with human serum albumin, forming a new antigenic determinant (F-HSA); this in turn causes the development of anti F-HSA antibodies. Finally, Thrasher et al.22 described that exposure to FA produces genotoxic and cytotoxic effects such as increased chromosomal aberrations, sister chromatids exchange, and presence of micronuclei.

Since FA is a compound widely used at industrial level, multiple research works have been developed using genotoxicity tests to identify the risks that occupational exposure to this chemical poses to the health of workers, showing possible damage to DNA. The objective of this study is to review recent research on occupational exposure to FA to design a strategy for monitoring and surveillance of workers occupationally exposed to this substance.

Materials and methods

A literature review was conducted in PubMed, MedLine, ScienceDirect, and Embase looking for human studies published between 2013 and 2017 in English or Spanish. The following descriptors were used: "occupational exposure", "formaldehyde", "mutagenicity test" and "DNA adducts", their Spanish equivalents and their combinations ("occupational exposure AND formaldehyde AND mutagenicity test OR mutagenicity test AND DNA adducts"). This search retrieved 103 articles whose titles and abstracts were analyzed.

Of the articles available in full text, those that met the following inclusion criteria were selected: assessed only exposure to FA, were conducted in occupational settings, and had quantitative results of airborne FA concentrations or genotoxicity tests that report the analytical technique used. In-vitro studies were excluded. Moreover, legal and technical sources were consulted to search publications that frame and regulate the monitoring of occupationally exposed workers (OEW) in Colombia, which should address the following issues: occupational exposure, medical monitoring, environmental concentration limits, FA and occupational cancer. Figure 1 shows the search flowchart.

Source: Own elaboration.

Figure 1 Search flowchart. 

Results

The 36 articles that met the inclusion and exclusion criteria were included. Most of the papers were observational studies in which the concentration of FA was quantified, and genotoxicity tests were performed to establish the relationship between exposure to FA and the health consequences among OEW. Some of the health effects reported in the articles include acute responses such as airway and eye irritation, while chronic effects were analyzed by means of genotoxicity biomarkers,23 which allow identifying and characterizing the damages that can be caused by this pollutant. Table 1 presents the results of the included articles that were considered most relevant to the objective of this study.

Table 1 Formaldehyde concentration and genotoxicity test in occupationally exposed workers. 

NIOSH: National Institute for Occupational Safety and Health; MN: micronucleus; OSHA: Occupational Safety and Health

Administration; HPLC-UV: high-performance liquid chromatography-ultraviolet; UV-Vis: ultraviolet-visible spectroscopy;

FA: formaldehyde; GC-FID: gas chromatography - flame ionization detector; PID: photoionization detector.* Mean±SD.

† Photoionization detector (11.7 eV lamp) with simultaneous video recording.

* Chromosome damage and DNA-protein cross-links in peripheral blood lymphocytes.

Source: Own elaboration.

The studies included in this review were carried out in Europe (38%), Asia (31%), South America (19%) and Africa (12%) in different working sectors, including the practice and teaching of health sciences, industrial manufacturing processes, and cosmetics production. The concern generated worldwide by occupational exposure to FA is evident in the increase in research on the subject in different work environments.

Discussion

Formaldehyde concentrations in working environments

According to the criteria of the United Nations' Globally Harmonized System of Classification and Labeling of Chemicals,37 any solution containing a carcinogenic substance beyond a concentration of 0.1% should be considered carcinogenic; however, 5% of FA solutions are used for cadaver dissection. Saowakon et al.12 reported concentrations of FA above permissible limits in both the air and the breathing zone of anatomy laboratory workers.

The concentration of FA can be quantified through standardized methods using different analytical techniques proposed by entities such as the Occupational Safety and Health Administration and the National Institute for Occupational Safety and Health. Table 2 depicts the methods used in the articles included in the review.

Table 2 Methods for quantifying formaldehyde in work environments. 

Agency Method Analytical technique
NIOSH 3500 UV-Vis UV-visible spectrophotometry
NIOSH 2541 GC-FID Gas chromatography - flame ionization detector
OSHA 1007 HPLC High-performance liquid chromatography
OSHA 52 GC-NPD Gas chromatography -Nitrogen phosphorous detector
NIOSH 2016 HPLC-UV High-performance liquid chromatography-UV detection
NIOSH 3800 FTIR Fourier transform infrared spectroscopy

NIOSH: National Institute for Occupational Safety and Health; OSHA: Occupational Safety and Health Administration.

Source: Own elaboration based on Kennedy,38 Occupational Safety and Health Administration39 and Kennedy & Williams40.

The highest concentrations of FA were found in studies conducted in China,32 Colombia3 and Tunisia,36 while the lowest concentrations, with values below permissible exposure limits, were found in a research conducted at a wood manufacturing center in Brazil.26 Studies by Lin et al.32 and Ghasemkhani et al.41 in China and Iran, respectively, found statistically significant differences in FA concentrations in the breathing zone of workers with the same job position depending on shift distribution and task performed.

The studies by Saowakon et al.12 and Ladeira et al.35, conducted in anatomical dissection laboratories, reported that the environmental concentration of FA in the breathing area of students and instructors was statistically different from the concentration found by fixed measurements in that area, the latter being higher.

In the articles included, the lack of engineering control systems, such as ventilation systems, extraction booths, localized extraction systems, among others, was identified. These systems would allow minimizing the concentration of FA in work environments.

Concerning medical surveillance, in 2015, Peteffi et al.42 conducted a study on workers of the furniture manufacturing industry in Brazil who were exposed to different levels of FA. The authors found that the levels of formic acid in urine were significant only in workers exposed to high concentrations of this compound.

In a study conducted at the University of Erlangen-Nuremberg, Schmid et al.43 compared the levels of formic acid in urine of 70 people not occupationally exposed to FA to the levels of 30 medical students attending anatomy classes during their practice with high exposure levels for a short period and of 8 pathology laboratory workers with long exposure periods. FA concentrations in the group of students were 0.32-3.48ppm and the levels of formic acid in urine fluctuated, so they were associated with the diet and not with the amount of FA in the air (p=0.070). In the group of workers, there was also no linear correlation between the levels of formic acid in urine and the concentrations of this pollutant in the air.

In 2010, Mautempo et al.44 conducted a study on 31 workers, in whom they found significantly elevated levels (p<0.0001) of formic acid in urine compared to the control group. However, the results do not describe the environmental concentration of FA, so no relationship can be established between concentrations of formic acid in urine and exposure to the pollutant.

Genotoxicity testing in workers occupationally exposed to formaldehyde

In two studies conducted in 2016 by Peteffi et al.26 in a furniture factory and Peteffi et al.27 in beauty salons, no significant differences were observed in the micronucleus test between OEW and the control group, while the comet assay showed significant differences, even though the workers were exposed to low concentrations of FA. These results are similar to those described by Zendehdel et al.,24 who observed that DNA damage in peripheral blood lymphocytes can occur even in controlled work environments. For their part, Ladeira et al.45 reported an increase in the frequency of micronuclei in exfoliated buccal cells and in peripheral blood lymphocytes in OEW and found significant differences compared to the control group.

Regarding the use of genotoxicity biomarkers, in a study carried out on workers in the cosmetics manufacturing industry, Attia et al.28 proposed that malondialdehyde (MDA), a metabolite and reactive oxygen species resulting from lipid peroxidation, and the mutation of the p53 gene, a known indicator of carcinogenesis, could be considered biomarkers of genotoxicity, as they found statistically significant differences in these two biomarkers between the OEW and the control group.

In an investigation conducted on 84 workers from the pathological anatomy service of different hospitals in Portugal, who were exposed to FA at levels higher than those allowed, Costa et al.8 found chromosomal aberrations and aneuploidies in the population studied through a structural chromosomal aberration test and a comet assay.

Furthermore, two systematic reviews were included, one by Fenech et al. ,29 who found significant differences in micronucleus frequency between workers exposed to high concentrations of FA and the control group in 17 of the 21 included studies, and another by Chiarella et al.,46 who proposed protein adducts as a potential biomarker after reviewing 95 studies.

Toxicological aspects of formaldehyde

Toxicokinetics

FA is produced endogenously in small quantities as part of the human body's metabolism. Its blood concentration reaches about 1.5-3 mg/L and is generated in processes such as methylamine deamination, methanol oxidation and histone demethylation by cytosolic alcohol dehydrogenase.14

When individuals are exposed to FA exogenously, this compound is absorbed by inhalation or ingestion. Therefore, the upper respiratory tract is its main route of entry into the human body and the nasal and nasopharyngeal mucosa are its target tissues; it has not been found significantly in other organs. Figure 2 shows the metabolic pathways that take place after entering the body.47 FA can be converted to methanol by the alcohol dehydrogenase-1 (ADH1) enzyme or oxidized to formate. Mitochondrial oxidation is catalyzed by the formaldehyde or aldehyde dehydrogenase-2 (ALDH2) enzyme, while cytoplasmic oxidation is catalyzed by the alcohol dehydrogenase-3 (ADH3) enzyme to form S-formylglutathione and then formate.46 Once formate is incorporated into the metabolic pathways, it can continue to oxidize towards carbon dioxide; another secondary metabolic pathway dependent on the tetrahydrofolate cofactor has also been reported.46 Moreover, FA acts by creating reversible or irreversible adducts with macromolecules(RNA, RNAand proteins), which leads to mutations and proliferation of micronuclei in the cells.14 MacAllister et al.48 evaluated the excretion pathways of this pollutant in animal models and concluded that the main pathway is exhalation (40%), followed by urine (17%), and feces (4%).

Source: Own elaboration.

Figure 2 Formaldehyde metabolic pathways  

Toxicodynamics

Although the exact mode of action that causes the irritant effect of FA is not yet well known, since this compound is an aldehyde, it is expected to react easily with the free amino acid groups to produce hydroxymethyl and a free radical (hydrogen proton). It has also been proposed that formaldehyde dehydrogenase becomes saturated when intracellular levels of FA are elevated, limiting natural protection mechanisms and making it easier for this xenobiotic to generate acute or chronic effects in the human body.16,49

Genotoxic effects

Cytotoxicity caused by exposure to FA has been proven through nasal biopsies performed on OEW, in whom chronic inflammation, mild epithelial dysplasia, loss of respiratory cilia, hyperplasia, squamous metaplasia of the epithelium and cancer of the nasopharynx and sinuses were observed.14,50 The toxic effects produced by FA metabolism in the human body that have been identified so far are gene mutation, chromosomal breakage, aneuploidy, epigenetic alterations, oxidative stress, cytotoxicity and induction of cell proliferation.15

In studies using cultures of human cells in vivo, Peteffi et al.26 and Shaham et al.51 showed that FA can produce genotoxicity, as it causes DNA damage and chromosome changes, often expressed as chromosome aberrations, DNA adducts, sister chromatid exchange and micronuclei. Additionally, it has been reported that this compound damages hematopoietic progenitor cells in vitro, which increases its possible relationship with hematological diseases such as acute myeloid leukemia.15,16

Formaldehyde and formic acid as biomarkers of exposure

Although attempts have been made to determine the exogenous concentration of FA in blood, it cannot be used as a biomarker of exposure since only a very low inhaled fraction of FA enters the blood stream. Moreover, the half-life of FA in peripheral blood is 1 to 1.5 minutes, its high reactivity allows it to transform rapidly into other compounds, and the metabolic buffering capacity of the body's nasal cells keeps its levels in blood in the range of 2-3 mg/L.52

Formic acid can be a biomarker of exposure since it is a metabolite of FA excreted in urine; however, its use has been controversial because of its inter-individual variability and the influence of factors such as smoking, diet and nutritional status on the levels of this acid in urine. Also, formic acid can be produced from other substrates of metabolism, so it is not a specific biomarker for detecting exposure to FA. Therefore, Peteffi et al.42 suggested that it could be a biomarker with interferences in its outcome, while Schmid et al.43 concluded that the results of formic acid in urine do not allow assessing exposure to FA, even when the concentration of this pollutant in the working environment is above 50% of the permitted limit.

Genotoxic effects and biomarkers of genotoxicity

Most studies included in the review agree on reporting two biomarkers of genotoxicity: the micronucleus assay on exfoliated cells from the buccal mucosa to visualize local damage, and the comet assay on peripheral blood lymphocytes to identify systemic damage.53 Usually, two genotoxicity tests are done, although the results do not always coincide.

Fenech et al.29 and Chiarella et al.46 do not recommend the use of formic acid in urine or genotoxicity tests since they may be altered by exposure to other xenobiotics and, therefore, they may not be conclusive. However, the studies conducted by these authors were limited to animal models.

Souza & Devi30 and Pira et al.54 agree that the damage caused by FA is directly proportional to years of exposure and concentration in the work environment. This is consistent with Lin et al.,32 who established a relationship between FA concentration and time of exposure, and genotoxic damage.

As for immunotoxicity, Jia et al.,55 Aydin et al.33 and Seow et al.56 reported decreased immune cells and immunoglobulin production, as well as DNA damage. This was evaluated using a comet assay, which suggests that exposure to FA caused immunosuppression in the populations studied, which, in turn, may be associated with diseases of the myeloid system and may explain the mechanism of damage of FA cytotoxicity.

Although genotoxicity biomarkers are not specific for establishing exposure to FA, they provide information on the possible health effect of this pollutant on OEW, taking into account its mechanism of damage, which may facilitate preventive decision-making; therefore, evaluating their usefulness is suggested for individual surveillance. Formic acid in urine as a biomarker does not provide consistent information on exposure to FA, nor does it work to identify cases; on the contrary, it creates confusion and its results can cause the implementation of erroneous intervention and follow-up strategies.

Occupational exposure limits

Although FA is found naturally in the air, there is an increase in its concentration in the most populated urban areas caused mainly by anthropogenic sources. In rural areas, airborne FA concentrations are generally <1 µg/m3, while in urban environments levels are approximately 0.16ppm.14 Garcia-Reynoso et al.57 reported that FA is the environmental pollutant with the highest concentration in Mexico City, increasing the probability of suffering from cancer; consequently, this result is associated with a decrease in life expectancy of the inhabitants of this city.

Regulatory agencies have established permissible limits for FA in work environments according to time of exposure to protect workers' health (Table 3). In 2012, the European Chemicals Agency Risk Assessment Committee concluded that the lowest adverse effects concentration of FA is 2ppm, causing histopathological lesions, polypoid adenomas, and cell proliferation.58

Table 3 Permissible limits for exposure to formaldehyde. 

Agency Permissible limit ppm mg/m3
American Conference of Governmental Industrial Hygienists TLV - TWA * 0.1 -
American Conference of Governmental Industrial Hygienists TLV - STEL t 0.3 -
Occupational Safety and Health Administration PEL - TWA 0.75 0.93
Occupational Safety and Health Administration STEL 2 -
National Institute of Occupational Safety and Health REL - TWA 0.016 -
National Institute of Occupational Safety and Health CEILING * 0.1 -

TLV: threshold limit value; TWA: time weighted average; STEL: short term exposure limit; PEL: permissible exposure limit; REL: recommended exposure limit.

* Maximum concentration for 8 hours per day and 40 hours per week.

† Concentration that should not be reached when working for 15-minute periods, maximum 4 times per day, leaving a

1-hour rest period between exposures.

‡ Concentration to which workers should never be exposed during their work shift.

Source: Own elaboration based on the American Conference of Governmental Industrial Hygienists.59

The concentrations reported in most of the articles included in the review exceed the allowable limits proposed by the American Conference of Governmental Industrial Hygienists (TLV-TWA=0.1ppm),59 indicating high exposure to FA in the populations studied.

The selection of the analytical technique to quantify FA depends on the level of sensitivity desired, the technology available, and the possible interferences present in the environment to be evaluated. The most used methods of analysis are NIOSH 350038 and NIOSH 2016,40 which use the ultraviolet-visible spectrophotometry (UV-Vis) analytical technique. The studies by Peteffi et al.26 and Peteffi et al.,27 carried out in 20l6 in Brazil, utilized passive monitoring systems because they are easier to use since they do not require a sampling pump.

Control strategies

The studies included in the review showed the lack of control systems, such as extraction booths and ventilation systems, that reduce the concentration of FA in work environments.41 In people who perform body dissection activities in anatomy laboratories, eye and nasal irritation and the sensation of fatigue seem to be constant symptoms.31 Even though the effect of FA can be reduced by using personal protective equipment, students and professors of the health area rarely use it,60 and the same thing happens among workers in other work environments.30 As described by Saowa-kon et al.12, only a small proportion of the population reported wearing goggles and, despite their use, they did not perceive the decrease in eye irritation; therefore, it is concluded that their use does not minimize the worker's exposure to FA. For their part, workers included in the Costa et al. study8 reported not wearing goggles or respiratory protection, as these elements interfered with activities such as note taking, material handling, and communication.

Even though exposure to FA can be monitored, it is always recommended to consider the substitution of this compound by less hazardous substances for health, considering that it is classified as a carcinogenic substance for humans. For example, Rocha-Ferreira et al.61 studied a solution of ethanol and glycerol for the preservation of corpses, achieving results that can be replicated.

Preference should be given to the establishment of closed processes in which the worker has no contact with this pollutant and perform engineering controls that minimize its presence in the work environment. Furthermore, these measures should be included when technology and production systems are updated, applying control strategies according to their hierarchy: first at the source, then in the environment, and finally in the worker.

Conclusions

According to the Colombian regulations,1,62,63 employers must periodically evaluate the levels of exposure of workers to chemicals considered a priority. In other words, potentially carcinogenic agents should be monitored to determine the risk they pose to OEW, the effectiveness of the control systems in place, and perform relevant medical follow-up. However, care guidelines for occupational exposure to FA have not yet been established.

Strategies implemented as part of the surveillance system often include workplace environmental measurements, spirometry, and formic acid test in urine, although the latter is not a reliable biomarker of FA exposure. Therefore, based on the articles included in this review, we propose a sequence of actions to carry out the epidemiological surveillance of OEW and present biomonitoring alternatives for this population (Figure 3).

FA: formaldehyde; JSA: job safety analysis; OEW: occupationally exposed workers; OME: occupational medical examination; TLV: threshold limit value; RI: risk index; MN: macronuclei. Source: Own elaboration.

Figure 3 Flowchart for epidemiological surveillance of workers occupationally exposed to formaldehyde.  

Additionally, acute symptoms and chronic injuries should be monitored, and the use of respiratory protection should be implemented whenever workers are exposed to FA. This seeks to reduce the damages caused by this pollutant since harmful effects could occur even if exposure is at low concentrations.14,24,26

Occupational environmental measurements should be made in the breathing area of the OEW; no fixed environmental measurements should be made, as the results are statistically different. FA in blood and formic acid in urine are not reliable biomarkers of exposure to this compound, since they are not very sensitive and specific, and their results can be affected by different factors. Genotoxicity markers are a better option for identifying the mechanism of FA damage and for medical follow-up of OEW.

The proper management of the risk derived from occupational exposure to FA, as well as the appropriate medical follow-up of these workers, requires the implementation of a series of interdisciplinary actions that allow the creation of a comprehensive occupational surveillance system of OEW to this substance, taking into account that it is currently the most used preservative to manufacture multiple products.

Acknowledgements

To the master's degree in Toxicology of the Faculty of Medicine of the Universidad Nacional de Colombia, Bogotá Campus, for expanding our knowledge and motivating us to carry out the study.

To Angélica María Ramírez Martínez, for her valuable contributions.

References

1. Colombia. Ministerio del Trabajo. Resolución 0312 de 2019 (febrero 13): Por la cual se definen los Estándares Mínimos del Sistema de Gestión de la Seguridad y Salud en el Trabajo SG-SST. Bogotá D.C.: febrero 13 de 2019 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2Ddnqzr . [ Links ]

2. Sistema de Vigilancia Epidemiológica del Cáncer Ocupacional en Colombia. Por la prevención del cáncer ocupacional en Colombia. Bogotá D.C.: Ministerio del Trabajo, Instituto Nacional de Cancerología; 2014. Available from: https://bit.ly/3fbBbMM. [ Links ]

3. Casas-Duarte J. Caracterización de la exposición ocupacional a formaldehído en trabajadores del sector salud y educación en Colombia 2004-2013 [tesis maestría]. Bogotá D.C.: Universidad del Rosario; 2015. [ Links ]

4. Idrobo-Avila EH, Vasquez-López JA, Vargas-Cañas R. La exposición ocupacional al formol y la nueva tabla de enfermedades laborales. Rev Salud Pública. 2017;19(3):382-5. http://doi.org/d2zw. [ Links ]

5. Colombia. Ministerio del Trabajo. Decreto 1477 de 2014 (agosto 5): Por el cual se expide la Tabla de Enfermedades Laborales. Bogotá D.C.: agosto 5 de 2014 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2VLHkYJ . [ Links ]

6. Instituto Nacional de Seguridad e Higiene en el Trabajo. Formaldehído en la industria de fabricación de tableros. Madrid: INSHT; 2016. Available from: https://bit.ly/38sG95n. [ Links ]

7. International Agency for Research on Cancer. Chemical agents and related occupations. Volume 100 F. A review of human carcinogens. Lyon: IARC; 2012 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2DaEsy1 . [ Links ]

8. Costa S, Carvalho S, Costa C, Coelho P, Silva S, Santos LS, et al. Increased levels of chromosomal aberrations and DNA damage in a group of workers exposed to formaldehyde. Mutagenesis. 2015;30(4):463-73. http://doi.org/f7jws4. [ Links ]

9. Casset A, Marchand C, Purohit A, le Calve S, Uring-Lambert B, Donnay C, et al. Inhaled formaldehyde exposure: effect on bronchial response to mite allergen in sensitized asthma patients. Allergy. 2006;61(11):1344-50. http://doi.org/c3s8pz. [ Links ]

10. Rajaeifard A, Neghab M. Ventilatory disorder induced by formaldehyde exposure. Toxicol Lett. 2006;164:S122. http://doi.org/c586bc. [ Links ]

11. Mathur N, Rastogi SK. Respiratory effects due to occupational exposure to formaldehyde: Systematic review with meta-analysis. Indian J Occup Environ Med. 2007; 11(1):26-31. http://doi.org/dqfd3k. [ Links ]

12. Saowakon N, Ngernsoungnern P, Watcharavitoon P, Ngernsoungnern A, Kosanlavit R. Formaldehyde exposure in gross anatomy laboratory of Suranaree University of Technology: a comparison of area and personal sampling. Environ Sci Pollut Res Int. 2015;22(23):19002-12. http://doi.org/f72f5f. [ Links ]

13. Lakchayapakorn K, Watchalayarn P. Formaldehyde exposure of medical students and instructors and clinical symptoms during gross anatomy laboratory in Thammasat University. J Med Assoc Thai. 2010;93(Suppl 7):S92-8. [ Links ]

14. International Agency for Research on Cancer. IARC Monographs on the Evaluation of Carcinogenic Risks to Humans. Volume 88. Formaldehyde, 2-Butoxyethanol and 1-tert-Bu-toxypropan-2-ol. Lyon: IARC; 2006 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2AtiXr5 . [ Links ]

15. Mundt KA, Gallagher AE, Dell LD, Natelson EA, Boffetta P, Gentry PR. Does occupational exposure to formaldehyde cause hematotoxicity and leukemia-specific chromosome changes in cultured myeloid progenitor cells? Crit Rev Toxicol. 2017;47(7):592-602. http://doi.org/d2zx. [ Links ]

16. Zhang L, Steinmaus C, Eastmond DA, Xin XK, Smith MT. Formaldehyde exposure and leukemia: A new meta-analysis and potential mechanisms. Mutat Res. 2009;681(2-3): 150-68. http://doi.org/b2dpfb. [ Links ]

17. World Health Organization. Concise International Chemical Assessment Document 40. Formaldehyde. Stuttgart: WHO; 2002 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2Au59g2 . [ Links ]

18. Checkoway H, Dell LD, Boffetta P, Gallagher AE, Crawford L, Lees PS, et al. Formaldehyde Exposure and Mortality Risks From Acute Myeloid Leukemia and Other Lymphohematopoi-etic Malignancies in the US National Cancer Institute Cohort Study of Workers in Formaldehyde Industries. J Occup Environ Med. 2015;57(7):785-94. http://doi.org/f7jnvp. [ Links ]

19. Lino-dos-Santos-Franco A, Correa-Costa M, Cardoso-dos Santos-Durao AC, Ligeiro-de Oliveira AP, Breithaupt-Faloppa AC, de Almeida-Bertoni J, et al. Formaldehyde induces lung inflammation by an oxidant and antioxidant enzymes mediated mechanism in the lung tissue. Toxicol Lett. 2011; 207(3):278-85. http://doi.org/dqj6m2. [ Links ]

20. Schwensen JF, Friis UF, Menné T, Flyvholm MA, Johansen JD. Contact allergy to preservatives in patients with occupational contact dermatitis and exposure analysis of preservatives in registered chemical products for occupational use. Int Arch Occup Environ Health. 2017;90(4):319-33. http://doi.org/f94xvw. [ Links ]

21. Thrasher JD, Broughton A, Micevich P. Antibodies and immune profiles of individuals occupationally exposed to formaldehyde: Six case reports. Am J Ind Med. 1988;14(4):479-88. http://doi.org/dz6rbn. [ Links ]

22. Thrasher JD, Wojdani A, Cheung G, Heuser G. Evidence for Formaldehyde Antibodies and Altered Cellular Immunity in Subjects Exposed to Formaldehyde in Mobile Homes. Arch Environ Health. 1987;42(6):347-50. http://doi.org/d923z5. [ Links ]

23. Swenberg JA, Moeller BC, Lu K, Rager JE, Fry RC, Starr TB. Formaldehyde Carcinogenicity Research: 30 Years and Counting for Mode of Action, Epidemiology, and Cancer Risk Assessment. Toxicol Pathol. 2013;41(2):181-9. http://doi.org/d2zz. [ Links ]

24. Zendehdel R, Jouni FJ, Hajipour B, Panjali Z, Kheiri H, Vahabi M. DNA damage in workers exposed to formaldehyde at concentrations below occupational exposure limits. Toxicol Environ Chem. 2017;99(9-10):1409-17. http://doi.org/d2z2. [ Links ]

25. Ladeira C, Pádua M, Veiga L, Viegas S, Carolino E, Gomes MC, et al. Influence of Serum Levels of Vitamins A, D, and E as well as Vitamin D Receptor Polymorphisms on Micronucleus Frequencies and Other Biomarkers of Genotoxicity in Workers Exposed to Formaldehyde. J Nutrigenet Nutrigenomics. 2015;8(4-6):205-14. http://doi.org/d2z3. [ Links ]

26. Peteffi GP, da Silva LB, Antunes MV, Wilhelm C, Valandro ET, Glaeser J, et al. Evaluation of genotoxicity in workers exposed to low levels of formaldehyde in a furniture manufacturing facility. Toxicol Ind Health. 2016;32(10):1763-73. http://doi.org/d2z4. [ Links ]

27. Peteffi GP, Antunes MV, Carrer C, Valandro ET, Santos S, Glaeser J, et al. Environmental and biological monitoring of occupational formaldehyde exposure resulting from the use of products for hair straightening. Environ Sci Pollut Res Int. 2016;23(1):908-17. http://doi.org/d2z5. [ Links ]

28. Attia D, Mansour N, Taha F, Seif-El Dein A. Assessment of lipid peroxidation and p53 as a biomarker of carcinogenesis among workers exposed to formaldehyde in the cosmetic industry. Toxicol Ind Health. 2016;32(6):1097-105. http://doi.org/d2z6. [ Links ]

29. Fenech M, Nersesyan A, Knasmueller S. A systematic review of the association between occupational exposure to formaldehyde and effects on chromosomal DNA damage measured using the cytokinesis-block micronucleus assay in lymphocytes. Mutat Res. 2016;770:46-57. http://doi.org/f9g2r7. [ Links ]

30. Souza AD, Devi R. Cytokinesis blocked micronucleus assay of peripheral lymphocytes revealing the genotoxic effect of formaldehyde exposure. Clin Anat. 2014;27(3):308-12. http://doi.org/f5vzgk. [ Links ]

31. Watchalayann P, Tapyai A, Lakchayapakorn K. Area and Personal Exposure Levels to Formaldehyde and Its Variation among Undergraduate Students during Gross Anatomy Laboratory Practice. EnvironmentAsia. 2014;7(2):54-9. [ Links ]

32. Lin D, Guo Y, Yi J, Kuang D, Li X, Deng H, et al. Occupational Exposure to Formaldehyde and Genetic Damage in the Peripheral Blood Lymphocytes of Plywood Workers. J Occup Health. 2013;55(4):284-91. http://doi.org/d2z7. [ Links ]

33. Aydin S, Canpinar H, Úndeger Ú, Gúç D, Çolakoglu M, Kars A, et al. Assessment of immunotoxicity and genotoxicity in workers exposed to low concentrations of formaldehyde. Arch Toxicol. 2013;87(1):145-53. http://doi.org/f4gt86. [ Links ]

34. Costa S, García-Lestón J, Coelho M, Coelho P, Costa C, Silva S, et al. Cytogenetic and Immunological Effects Associated with Occupational Formaldehyde Exposure. J Toxicol Environ Health A. 2013;76(4-5):217-29. http://doi.org/d2z8. [ Links ]

35. Ladeira C, Viegas S, Carolino E, Gomes MC, Brito M. The influence of genetic polymorphisms in XRCC3 and ADH5 genes on the frequency of genotoxicity biomarkers in workers exposed to formaldehyde. Environ Mol Mutagen. 2013;54(3): 213-21. http://doi.org/f4q9d4. [ Links ]

36. Bouraoui S, Mougou S, Brahem A, Tabka F, Ben-Khelifa H, Harrabi I, et al. A Combination of Micronucleus Assay and Fluorescence In Situ Hybridization Analysis to Evaluate the Genotoxicity of Formaldehyde. Arch Environ Contam Toxicol. 2013;64(2):337-44. http://doi.org/f4pzcj. [ Links ]

37. Naciones Unidas. Sistema Globalmente Armonizado de Clasificación y Etiquetado de Productos Químicos (SGA). 6th ed. Ginebra: Naciones Unidas; 2015 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2ZB5BSh . [ Links ]

38. Kennedy ER. Formaldehyde: Method 3500. In: The National Institute for Occupational Safety and Health, editor. Manual of Analytical Methods. 4th ed. USA: NIOSH; 1994 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/38DDy93 . [ Links ]

39. Occupational Safety and Health Administration. Acrolein and/ or Formaldehyde. USA: OSHA [cited 2020 Jun 04]. Available from: Available from: https://bit.ly/3e73uLn . [ Links ]

40. Kennedy ER, Williams K. Formaldehyde: Method 2541. In: The National Institute for Occupational Safety and Health, editor. Manual of Analytical Methods. 4t h ed. USA: NIOSH ; 1994 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/3f3trwC . [ Links ]

41. Ghasemkhani M, Jahanpeyma F, Azam K. Formaldehyde Exposure in Some Educational Hospitals of Tehran. Ind Health. 2005;43(4):703-7. http://doi.org/cjcnc3. [ Links ]

42. Peteffi GP, Basso-da Silva L, Zilles-Hahn R, Antunes MV, Rhoden L, Anschau ME, et al. Simple and fast headspace-gas chromatographic determination of formic acid in urine: application to the assessment of occupational exposure to formaldehyde. Applied Research in Toxicology. 2015 [cited 2020 Jul 04];1(1):40-5. Available from: Available from: https://bit.ly/2ZBGm2e . [ Links ]

43. Schmid K, Schaller KH, Angerer J, Lehnert G. Untersuchungen zur Dignitát der Ameisensáureausscheidung im Harn für umwelt- und arbeitsmedizinische Fragestellungen. Zentralbl Hyg Umweltmed. 1994;196(2):139-52. [ Links ]

44. Mautempo C, Bastos MDL, Carvalho F, Remiao F, Carmo H, Guedes-De-Pinho P. Determination of formic acid in urine of workers occupationally exposed to formaldehyde. Toxicol Lett. 2010;196:S74. http://doi.org/dcdxmb. [ Links ]

45. Ladeira C, Viegas S, Carolino E, Prista J, Gomes MC, Brito M. Genotoxicity biomarkers in occupational exposure to formaldehyde - The case of histopathology laboratories. Mutat Res. 2011;721(1):15-20. http://doi.org/b9g387. [ Links ]

46. Chiarella P, Tranfo G, Pigini D, Carbonari D. Is it possible to use biomonitoring for the quantitative assessment of formaldehyde occupational exposure? Biomark Med. 2016;10(12):1287-303. http://doi.org/d2z9. [ Links ]

47. Tulpule K, Hohnholt MC, Dringen R. Formaldehyde metabolism and formaldehyde-induced stimulation of lactate production and glutathione export in cultured neurons. J Neurochem. 2013;125(2):260-72. http://doi.org/f4s9r3. [ Links ]

48. MacAllister SL, Choi J, Dedina L, O'Brien PJ. Metabolic mechanisms of methanol/formaldehyde in isolated rat hepatocytes: Carbonyl-metabolizing enzymes versus oxidative stress. Chem Biol Interact. 2011;191(1-3):308-14. http://doi.org/dtjrw6. [ Links ]

49. National Toxicology Program. DRAFT. Report on Carcinogens Substance Profile for Formaldehyde. USA: NTP; 2010 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/3dXi5IT . [ Links ]

50. National Toxicology Program. Report on Carcinogens. 14th ed. USA: Department of Health and Human Services, Public Health Service; 2016 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2VNUDYt . [ Links ]

51. Shaham J, Bomstein Y, Gurvich R, Rashkovsky M, Kaufman Z. DNA-protein crosslinks and p53 protein expression in relation to occupational exposure to formaldehyde. Occup Environ Med. 2003;60(6):403-9. http://doi.org/dncjpm. [ Links ]

52. Nielsen GD, Larsen ST, Wolkoff P. Recent trend in risk assessment of formaldehyde exposures from indoor air. Arch Toxicol. 2013;87(1):73-98. http://doi.org/gcbpxt. [ Links ]

53. Tolbert PE, Shy CM, Allen JW. Micronuclei and Other Nuclear Anomalies in Buccal Smears: A Field Test in Snuff Users. Am J Epidemiol. 1991;134(8):840-50. http://doi.org/d22b. [ Links ]

54. Pira E, Romano C, Verga F, La Vecchia C. Mortality from lymphohematopoietic neoplasms and other causes in a cohort of laminated plastic workers exposed to formaldehyde. Cancer Causes Control. 2014;25(10):1343-9. http://doi.org/f6mpcz. [ Links ]

55. Jia X, Jia Q, Zhang Z, Gao W, Zhang X, Niu Y, et al. Effects of Formaldehyde on Lymphocyte Subsets and Cytokines in the Peripheral Blood of Exposed Workers. PLoS One. 2014;9(8):e104069. http://doi.org/d22c. [ Links ]

56. Seow WJ, Zhang L, Vermeulen R, Tang X, Hu W, Bassig BA, et al. Circulating immune/inflammation markers in Chinese workers occupationally exposed to formaldehyde. Carcinogenesis. 2015;36(8):852-7. http://doi.org/f7nnfp. [ Links ]

57. García-Reynoso JA, Grutter M, Cintora-Juárez D. Evaluación del riesgo por contaminantes criterio y formaldehído en la Ciudad de México. 2007 [cited 2020 Jun 04];23(4):169-75. Available from: Available from: https://bit.ly/2CaEFk3 . [ Links ]

58. Gelbke HP, Gróters S, Morfeld P. Lowest adverse effects concentrations (LOAECs) for formaldehyde exposure. Regul Toxicol Pharmacol. 2014;70(1):340-8. http://doi.org/f6h6vf. [ Links ]

59. American Conference of Governmental Industrial Hygienists. The threshold Limit Values (TLVs®) and Biological Exposure Indices (BEIs®). United States: ACGIH; 2018. [ Links ]

60. D'Ettorre G, Criscuolo M, Mazzotta M. Managing Formaldehyde indoor pollution in anatomy pathology departments. Work. 2017;56(3):397-402. http://doi.org/f9s897. [ Links ]

61. Rocha-Ferreira J, Cardoso-Rezende L, De Souza-Barbosa A, De Carvalho P, De Lima NE, Assis-Carvalho A. Economic, human and environmental health benefits of replacing formaldehyde in the preservation of corpses. Ecotoxicol Environ Saf. 2017;145:490-5. http://doi.org/gb24cw. [ Links ]

62. Colombia. Ministerio del Trabajo. Decreto 1072 de 2015 (mayo 26): Por medio del cual se expide el Decreto Único Reglamentario del Sector Trabajo. Bogotá D.C.: Diario Oficial No. 49523; mayo 26 de 2015 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/2Z3DbS1 . [ Links ]

63. Colombia. Ministerio del Trabajo. Resolución 2400 de 1979 (mayo 22): Por la cual se establecen algunas disposiciones sobre vivienda, higiene y seguridad en los establecimientos de trabajo. Bogotá D.C.: mayo 22 de 1979 [cited 2020 Jul 04]. Available from: Available from: https://bit.ly/3dUG3EM . [ Links ]

Villadiego-Molinares MM, Ramírez-Martínez JA, Rodriguez-Pulido AI. Formaldehyde in occupational environments: literature review and an occupational health surveillance proposal. Rev. Fac. Med. 2020;68(3):425-37. English. doi: http://dx.doi.org/10.15446/revfacmed.v68n3.73188.

Villadiego-Molinares MM, Ramirez-Martinez JA, Rodriguez-Pulido AI. [For-maldehido en ambientes laborales: revisión de la literatura y propuesta de vigilancia ocupacional]. Rev. Fac. Med. 2020;68(3):425-37. English. doi: http://dx.doi.org/10.15446/revfacmed.v68n3.73188.

Conflicts of interest None stated by the authors.

Funding None stated by the authors.

Received: June 28, 2018; Accepted: January 31, 2019

*Corresponding author: Marisol Margarita Villadiego-Molinares. Departamento de Toxicologia, Facultad de Medicina, Universidad Nacional. Carrera 30 No. 45-03, building 471, office 2013. Telephone number: +571 3165000, ext. 1510. Bogotá D.C. Colombia. Email: mvilladiego@unal.edu.co.

Creative Commons License This is an open-access article distributed under the terms of the Creative Commons Attribution License